EPDM, the black rubber membrane, has half a century of track record on commercial roofs, and plenty of Dallas buildings are wearing it right now.
EPDM makes its case on longevity and repairability. The rubber tolerates decades of weather, and repairs are straightforward for crews who know the system. Its black surface absorbs Texas heat, a real operating-cost factor in Dallas, so new installs often weigh TPO first while existing EPDM roofs frequently earn repair and restoration instead of replacement. Our written estimates are free, and inspections are documented with photos so you can see seam and flashing condition yourself. We never waive deductibles because Texas law does not permit it, and we are not a public adjuster.
Keeping Dallas EPDM Roofs in Service
An EPDM roof in Dallas has to hold up to heat and hail. The city has seen 25 golf-ball-size hail days since 2006 and 77 days of inch-plus hail within 13 miles, with the largest stone at 4.25 inches on May 24, 2011. Rubber membranes can take impact without obvious marks, so a post-storm survey checks seams, penetrations, and drainage rather than only the surface. Age is the other factor. Dallas is an established city, with 48 percent of its housing built before 1980 and a median year of 1981, and many existing EPDM roofs here have years of patching behind them. A moisture survey tells us whether restoration will hold or whether the assembly has reached the end of its service. EPDM service calls across Dallas County reach Balch Springs and University Park on the same routes.
THE SYSTEM
EPDM Roofing, up close.
EPDM membrane. Fully-adhered black rubber in seamless sheets: the low-slope workhorse.
PUBLIC RECORD
The local record behind EPDM Roofing in Dallas
How a roof system holds up in Dallas depends on the storms it has to take and the houses it sits on. Here is what the public record shows.
77
Hail days, 1 in.+ since 2006
25
Golf-ball-size hail days
4.25 in.
Largest stone on record
1981
Median year homes built
Hail near Dallas
Hail is a regular event around Dallas. NOAA's Storm Events Database lists 77 separate days since 2006 with hail one inch or larger reported within 13 miles of the city, and on 25 of those days the stones reached golf ball size or bigger. Hail that size was reported in 20 of the last 20 years. The largest stones on record nearby measured 4.25 inches (grapefruit size) on May 24, 2011. The most recent report: 1.5-inch hail on June 2, 2026.
May 24, 2011: 4.25-inch hail (grapefruit size)
April 25, 2026: 3-inch hail (teacup size)
June 6, 2018: 3-inch hail (teacup size)
June 13, 2012: 3-inch hail (teacup size)
April 3, 2012: 2.75-inch hail (baseball size)
How old Dallas homes are
The median home in Dallas was built in 1981, and 48% of the city's 590,237 housing units predate 1980. Many of these houses are likely on their second roof or nearing the point where they need one.
Sources: NOAA National Centers for Environmental Information, Storm Events Database (hail reports since 2006 within 13 miles of Dallas); U.S. Census Bureau, American Community Survey 2020–2024 5-year estimates. Data pulled September 2026.
Common questions about epdm roofing in Dallas
Is EPDM outdated compared to TPO in Dallas?
No, different trade-offs. EPDM has the longest single-ply track record and repairs well; its black surface absorbs heat that white TPO reflects. Existing EPDM in sound condition usually argues for maintenance, not replacement.
How long does EPDM last?
Decades. Well-maintained EPDM commonly reaches twenty-five to thirty years, and restoration coatings can extend sound membranes further.
Does this material suit older Dallas homes?
Often, with eyes open: older decks get inspected board by board before any system goes down, and weight or structural questions get answered before quoting. The material conversation starts with what your specific roof can carry.
How often does hail hit Dallas?
NOAA's Storm Events Database lists 77 days since 2006 with hail one inch or larger reported within 13 miles of Dallas, including 25 days with golf ball size stones or bigger. Hail that size was reported in 20 of the last 20 years. The most recent report was 1.5-inch hail on June 2, 2026.
How old are most homes in Dallas?
The median home in Dallas was built in 1981, according to the U.S. Census Bureau's American Community Survey. 48% of the city's housing units predate 1980 and 14% were built in 2010 or later. Most homes here are well past the life of their original roof.
